Biofuel: Jatropha
 |
This article needs to be revised. Please rewrite the article according to the specifications below. Only remove this maintenance box after a thorough revision of this article. See the discussion page for more details or start a discussion there. In particular the following aspects and passages have been specified to be in need for a revision: |
Jatropha is not as promissing as some people think.
Jatropha is a feedstock for biofuels.
Jatropha curcas is a non-edible seeds bearing tree. The tree can grow in dry, arid land (e.g. marginal, low-fertility land) but is sensitive to humidity (e.g. flooding). As Jatropha curcas is not browsed by animals, it is traditionally often used as a natural fence.
Jatropha Growing
Correct pruning is vital to achieve high yields. Ideally, stems are pruned just above the ground to achieve bush-like plants with many branches. A good plant should have bunches of Jatropha fruits at every end of a branch. In the first years, patience is needed: Jatropha bushes need about 4 to 5 years until full production capacity is reached. Achievable yields then can reach 4 to 5 tons per ha per year.
When planted in a plantation, 1,300 plants can be found in 1 ha (2.5 meters between the planys, 3 meters between the rows). Then, 3.8 kg seeds/year/plant should be reached in theory. Yet, single bushes cannot be compared to bushes in plantations that easily (e.g. lower access to minerals, etc.), so the yield per tree will probably be a bit lower.
Jatropha Products
Jatropha Oil
Jatropha oil is a plant oil with some similar physical and chemical properties to diesel, which is why it is possible to run diesel engines on jatropha oil after some adaptations. The oil content of jatropha seeds is around 30-35%, so around 3 kg of seeds deliver one liter of oil.
- calorific content: Jatropha oil has a 7% lower calorific content than diesel. A greater quantity of Jatropha oil is needed when switching from diesel to jatropha oil.
- viscosity: Jatropha has a higher viscosity than fossil-fuel based diesel. Hence, at lower temperatures (in ares with colder climates) this can cause problems when running a diesel engines, especially during the start-up phase when both the engine and the fuel are relativly cool. More stress is put on the fuel pump, the filter and injectors. By installing heating coils around the fuel lines, this problem can be mitigated.
Jatropha Oil Extraction
Before extraction, the seeds are is usually dried and cleaned. Cleaning the seed is to eliminate foreign material that may damage the oil extraction machine, while heating the seeds by leaving them in the sun or by roasting them gently for ten minutes, improving oil extraction efficiency of the hand expellers. Oil extraction can be done by both hand and machine. Traditional oil extraction methods are highly labour intensive, requiring some 12 hours to produce one litre of oil. The process requires roasting the seed kernels, pounding them to a paste, adding water and boiling, and then separating the oil by skimming and filtering.
Seed Cake
Being rich in nitrogen, the seed cake of the oil extraction process is good excellent source of nutrients and can be applied as an organic fertilizer.
Also, the seed cake is a good feeding material for biogas plants.
Others
Jatropha is also used to grow mushrooms and to produce soap.
Further Reading
For further information see Electricity Generation from Vegetable Oil.
www.jatropha-alliance.org and its Jatropha Handbook
Fact Foundation Jatropha Handbook
